The Airheads Beemer Club is a non-profit club reclaiming the 'Legendary Motorcycles of Germany'
Please take a moment to read the DISCLAIMER.

[ ad supports Snowbum's website ]

Oil Coolers

http://bmwmotorcycletech.info/coolers.htm
50D
© Copyright, 2007, 2012, 2017, R. Fleischer

Why an oil cooler?

Air cooled motorcycles can run quite hot in some situations. This includes large amounts of throttle power for long periods of time; pulling a trailer or sidecar where a lot of engine power is needed; extremely bad traffic conditions; use of fairings in general (particularly fairing lower center pieces that are not ventilated). Engine cooling is obviously worse in quite hot weather. Your BMW Airhead engine has more than enough cylinder fins & head fins to dissipate enough engine heat in most circumstances, including some fairly extensive stop & go traffic, & modest speeds pulling a trailer or sidecar. But, there are limits.

For proper engine operation, lubrication, protection, etc., engine oil should operate in a reasonable temperature range after the engine has warmed up; not too cold, not too hot. The oil also needs proper viscosity over its expected temperature range in the engine. Usually, a multi-grade oil such as 20W50 is used in our Airheads. Quality 20W50 motorcycle oil is far better than the old single grades type of oils, & is quite adequate for most conditions, but a thinner oil might be wise if temperatures are at or below freezing; perhaps a 10W40. 10W50 and 15W50 oils are also available. Further information is here: http://bmwmotorcycletech.info/coldstarting.htm as well as my various oil articles, including http://bmwmotorcycletech.info/viscosity.htm and http://bmwmotorcycletech.info/oilessay.htm. Please refer to these various articles, and others as appropriate.  

This remainder of this article is only available for Airheads Beemer Club members. Please Log In..or..Click Here to join the Airheads Beemer Club, after which you will enjoy access this article and all members only content of the ABC web site. 

Return to Tech Tips

Connect to Snowbum's HomePage